Ashwaubenon, WI, USA
N405PC
Cessna 501
At 1623:41, the pilot requested taxi clearance. The Green Bay (GRB) tower (ATCT) told the pilot to taxi to runway 18. At 1626:47 the pilot said that he was ready for takeoff. The ATCT local controller (LC) told the pilot, "proceed on course, cleared for takeoff". At 1627:33, radar showed the airplane began to accelerate down runway 18. At 1628:17 the LC told the pilot to contact departure control. The pilot responded, "ah papa charlie we have a little problem here we're going to have to come back." The LC asked the pilot, "what approach would you like?" The pilot responded, "like to keep the vis." At 1628:35, the LC asked the pilot, "like the contact approach that what you're saying?" There was no response from the pilot. At 1628:50, GRB radar showed the airplane on a heading of 091 degrees, at an altitude of 855 feet msl (160 feet agl), and at an airspeed of 206 knots. The airplane was 1.28 miles southeast of the airport radar. Radar contact with the airplane was lost at 1628:55. A witness to the accident said, "It was snowing moderately at that time. The road was wet but not slippery. Crossing the intersection of Morning Glory Rd. & Main St., I noted a white private jet flying from the south. It was flying at approximately a 75-80 degree angle perpendicular to the ground with its left wing down & teetering slightly." The witness said, "It then crossed Main Street with the lower wing tip approximately 20 to 30 feet above the power wires. The plane became more perpendicular to the ground at a 90 degree angle with the left wing down & (and) lost altitude crashing into the Morning Glory Dairy warehouse building." An examination of the airplane revealed no anomalies. At 1638, GRB weather was reported as ceilings of 200 feet broken, 800 feet overcast, visibility 1/2 statute mile with snow and fog, temperature 32 degrees F, dew point 32 degrees F, winds 120 degrees at 3 knots, and an altimeter setting of 29.99 inches Hg. Witnesses at the FBO said the pilot arrived to pick up the airplane after 1600. The pilot was briefed by the mechanic as he did his walk around inspection of the airplane. The pilot then got into the airplane. The airplane was towed out and the tow bar removed. About two minutes later, the engines started. Less than five minutes after the engines started, the airplane taxied. The NTSB Audio Laboratory reviewed radio communications between ATCT and the pilot to determine from the speech evidence the pilot's level of psychological stress and workload. The examination indicated the pilot's speech characteristics were consistent with an increased stress/workload that might accompany a developing emergency. Referring to the pilot's final transmissions, "His unusually long reaction time suggests that he was distracted by competing cockpit priorities and/or was having a difficult time determining his answer, while his fast speech and microphone keying provide further evidence of an urgency to return to other cockpit activities." The report states that the pilot's statements remained rational and showed good word choice and grammar. "These factors, along with the relatively small change in fundamental frequency, suggest that the pilot did not reach an extreme level of stress."
HISTORY OF FLIGHT On April 2, 2001, at 1629 central daylight time, a Cessna 501, N405PC, operated by an airline transport pilot was destroyed when maneuvering on initial climb after takeoff, it impacted into the southwest wall of the Morning Glory Dairy cold storage facility in Ashwaubenon, Wisconsin. A post impact explosion and fire ensued. The cold storage facility was destroyed and an adjacent dairy production plant sustained minor damage. Instrument meteorological conditions prevailed at the time of the accident. The ferry flight was being operated on an instrument flight rules flight plan under the provisions of Title 14 CFR Part 91. The pilot was fatally injured. Seven employees in the Morning Glory Dairy cold storage facility were injured. Four of the employees sustained minor injuries. Three of the employees sustained serious injuries from burns. The cross-country flight originated at the Austin-Straubel International Airport (GRB), Green Bay, Wisconsin, at 1627, and was en route to Ft. Myers, Florida. At 1615:17, the pilot contacted GRB air traffic control tower (ATCT) and requested clearance to Southwest Florida International Airport (RSW), Ft. Myers, Florida. The ground controller (GC) told the pilot, he was cleared to RSW as filed, climb and maintain 3,000 feet mean sea level (msl), expect flight level 370, one-zero minutes after takeoff, departure frequency 119.4 Megahertz, and transponder code 2673. The pilot read back the clearance, "four zero five papa charlie cleared as filed three thousand three seven zero in ten one nineteen four two six seven three." At 1623:41, the pilot told the GRB ATCT GC, "and ground citation four zero five papa charlie with ah [ATIS (automatic terminal information service) information] whiskey ready to taxi, like [runway] one eight (8,200 feet by 150 feet, wet concrete) if we could." The GC told the pilot to taxi to runway 18. At 1626:47 the pilot told the GRB ATCT local controller (LC) that he was ready to takeoff on runway 18. The LC told the pilot, "citation four zero five papa charlie green bay tower runway one eight proceed on course cleared for takeoff". At 1627:33, GRB radar, located on the airport, showed the airplane began to accelerate down runway 18. At 1628:17 the LC told the pilot, "citation five papa charlie contact departure have a good day." The pilot responded, "ah papa charlie we have a little problem here we're going to have to come back." In his written statement, the LC said that the airplane was out of his sight when he told the pilot to contact departure control. At 1628:27, the LC asked the pilot, "roger and what approach would you like?" The pilot responded, "like to keep the vis." At 1628:35, the LC asked the pilot, "like the contact approach that what you're saying?" There was no response from the pilot. The LC said, "I then saw a radar return on the brite scope southeast of the airport." At 1628:42, GRB radar showed the airplane in a left turn heading 135 degrees, at an altitude of 1,055 feet mean sea level (msl), (approximately 360 feet above ground level - agl) and an airspeed of 182 knots. The airplane was approximately 1 mile south of the airport. At 1628:46, GRB radar showed the airplane on a heading of 113 degrees, at an altitude of 955 feet msl, (approximately 260 feet agl) and at an airspeed of 193 knots. At 1628:50, GRB radar showed the airplane on a heading of 091 degrees, at an altitude of 855 feet msl, (approximately 160 feet agl) and at an airspeed of 206 knots. Radar contact with the airplane was lost at 1628:55. At 1628:53, the LC transmitted, "zero papa charlie you still have the airport in sight?" At 1629:18, the LC transmitted, "citation zero papa charlie can you hear?" A witness to the accident said she was traveling east on Main Street toward the Morning Glory Dairy. "It was snowing moderately at that time. The road was wet but not slippery. Crossing the intersection of Morning Glory Rd. & Main St., I noted a white private jet flying from the south. It was flying at approximately a 75-80 degree angle perpendicular to the ground with its left wing down & teetering slightly. I first noticed the plane as it approached Main Street flying at that angle just south of & between Fitzgerald's and the Hilltop Auto Repair shops. It then crossed Main Street with the lower wing tip approximately 20 to 30 feet above the power wires. The plane became more perpendicular to the ground at a 90 degree angle with the left wing down & lost altitude crashing into the Morning Glory Dairy warehouse building." Several other witnesses also saw the airplane prior to the accident. One witness at a lumber yard northwest of the crash site saw the airplane approach from the south. This witness reported, "The plane was very low and banked steeply to the left." One witness at a truck company on Main Street said he saw the airplane come around the back of a building about 100 feet off the ground. This witness reported, "The plane was sideways about 50 yards away from our van bodies in the back. The plane was going at a good rate of speed. Then we heard it hit the building across the street." Another witness at the same location said he heard a loud bottle rocket-type sound. He looked up in the sky and saw "a white Lear jet." The witness said the airplane was "tilted almost 90 degrees." The witness said he saw the airplane crash into the side of the dairy. He said he felt and saw the explosion and immediately saw lots of smoke. AIRCRAFT INFORMATION The airplane was privately owned and operated for business and pleasure. Fixed base operator (FBO) repair station records indicated the airplane had 5,856.8 hours total airframe time. The airplane's owner said that he last flew the airplane from Springfield, Illinois, to GRB, in March 2001 (the owner's son confirmed the date of the flight as March 14, 2001). The owner said he filed his flight plan expecting to fly the ILS approach into the airport. At the time he filed his flight plan, the weather at GRB was a 200-foot ceiling and 1/2 mile visibility. He said that the weather at GRB was better when he arrived so he didn't fly the complete approach. The owner said that he brought the airplane to GRB to have routine inspections performed and to have some discrepancies fixed. The owner said that a body fuel tank installed several months earlier was experiencing an intermittent fuel leak and there was a problem with the autopilot. In altitude hold mode, the autopilot would porpoise the airplane. According to repair station mechanics and repair facility work orders, phase 1, 2, 3, 4, and 48 inspections were performed on the airplane between March 14 and March 28. One mechanic said they corrected several discrepancies that were identified to them. This mechanic said, "There was an autopilot pitch up problem." He said the autopilot pitch drive, vertical gyro, and autopilot computer were removed and sent to an avionics repair facility in Lincoln, Nebraska, to be inspected and if necessary, overhauled. Avionics repair facility records showed that the vertical gyro rotor was failing. The defective parts were replaced and the gyro was calibrated, inspected, and returned. The mechanic said that when they got the units back, they reinstalled them in the airplane. The mechanic said they ran the airplane's systems up and checked them. He recalled checking the autopilot system twice. All of the systems functioned normally. PERSONNEL INFORMATION The pilot held an airline transport pilot certificate with a multiengine land rating and Cessna 500 type rating, and with commercial privileges for single engine land and sea airplanes, issued on November 6, 1992. According to Federal Aviation Administration (FAA) aeromedical records, the pilot reported having 4,500 total flying hours at his most recent physical examination on September 22, 2000. The pilot also reported having flown 150 hours in the 6 months prior to the examination. An examination of copies of the pilot's logbook showed the pilot had 4,547.8 total flying hours. The logbook record showed the pilot had 3,567.2 hours as pilot in command, 244.6 hours in a Cessna 501, and 205.8 hours as pilot in command in a Cessna 501. The pilot completed a Cessna 550 simulator checkride on April 26, 2000. The logbook record also showed the pilot completed Cessna 650 recurrency training on February 27, 2001. The pilot held a second class medical certificate with limitations, "Must have glasses available, available for near vision", dated September 22, 2000. According to the pilot's wife, she and her husband left their home in Key West, Florida, on the morning of the accident at approximately 0700 eastern daylight time to go to the airport. They flew 170 miles from Key West to Fort Myers. The pilot's wife said that the fixed base operator gave the pilot a ride to the terminal. The pilot's wife said that the pilot was in good health. She said he did not use drugs, did not smoke or drink alcohol, had no trouble sleeping, and had no money problems. METEOROLOGICAL INFORMATION At 1556, GRB weather was reported as ceilings of 600 feet broken, 1,200 feet overcast, visibility 3/4 statute miles with light snow and mist, temperature 34 degrees Fahrenheit (F), dew point 32 degrees F, winds 160 degrees at 5 knots, and altimeter setting of 29.99 inches of Mercury (Hg). At 1638, GRB weather was reported as ceilings of 200 feet broken, 800 feet overcast, visibility 1/2 statute mile with snow and fog, temperature 32 degrees F, dew point 32 degrees F, winds 120 degrees at 3 knots, and an altimeter setting of 29.99 inches Hg. A review of security camera videotape taken from a lumberyard located approximately 720 feet west-northwest of the Morning Glory Dairy cold storage facility showed poor weather conditions prevailed within an hour of, and through the time of the accident. The videotape showed activity from four different camera locations. A date-time stamp was located in the upper-left corner of the screen. The videotape contained several hours of images. The videotape review was begun with the date-time stamp showing the date as 04/02/01 and the time as 1530:11. There was no camera image in the upper left quadrant. The lower left quadrant videotape images were of a warehouse entrance. The images shown in the upper right quadrant (camera 2) of the videotape were of an outdoor parking lot. The images shown in the lower right quadrant (camera 4) of the videotape were of an outdoor lumberyard. The images from cameras 2 and 3 were stationary the entire time. Camera 4 was adjustable and would pan left and right, and zoom in and out. The images in camera 2 showed light snow flurries began to fall at 1535. The snow intensified slightly at 1600 and continued through the end of the videotape at 1656:40. The images in camera 4 initially showed stacks of lumber up close. At 1538, camera 4 panned right to show the lumberyard. In these images, the pavement was observed to be wet. The outline of wooded areas and building structures could be faintly seen in the distance. The sky conditions were overcast. Camera 4 images showed light snow at 1553. At 1614, camera 4 panned right and then pulled back to show another part of the lumberyard. In these images the pavement was wet and the structures in the distance were faint. At 1629:05, smoke began to show in the upper right side of the camera 4 image. Camera 4 panned right and stopped to show heavy smoke and fire coming from a building. The building outline was very faint. The smoke continued to intensity until it filled the frame. The smoke images continued to be recorded by camera 4 until the end of the videotape. WRECKAGE AND IMPACT INFORMATION The National Transportation Safety Board (NTSB) on-scene investigation began at 2315. The airplane struck the roof and southwest wall of the Morning Glory Dairy cold storage facility at 3399 South Ridge Road in Ashwaubenon. The airplane penetrated through the building's roof and interior storage racks on an approximate magnetic heading of 030 degrees. The impact and subsequent explosion resulted in the airplane's fragmentation and destruction of the 40,000 square foot, 3-story building. The airplane's main wreckage came to rest in several locations on the floor of the cold storage facility. The majority of the airplane's main wreckage came to rest at the foot of dairy storage system rack row A, approximately 127 feet from where the airplane impacted the facility's southwest wall (see wreckage diagram). The main wreckage consisted of the airplane's nose section, cabin section, tail cone, left engine, horizontal stabilizer, portions of the right wing, and inboard section of the left wing. The remainder of the airplane's structure, with exception of the vertical stabilizer and top portion of the rudder, was scattered throughout the south and west parts of the facility. The centrifugal compressor from the left engine was found imbedded in an vertical air duct on top of an adjacent building, approximately 200 feet northeast of the cold storage facility. Several small pieces of airplane structure and engine components were found in the dairy's parking lot, north and northeast of the facility, within a 250-foot radius. The airplane's nose section, from the nose cone aft to fuselage station (FS) 94.0, to include the radar antennae, nose equipment bay, baggage section, and nose gear wheel well were broken aft, fragmented, charred, and melted. The nose gear was broken aft and fragmented. The nose gear doors were broken out, charred, and melted. The cockpit section, beginning at the forward pressure bulkhead (FS 94.0) was crushed and broken aft, fragmented, charred, and melted. The instrument panel was fragmented, charred, and melted. Flight, engine, and navigation instruments were broken out, crushed, charred, melted, and consumed by fire. The control yokes, rudder pedals, center console, and pilot seats were broken out and charred. The glareshield, and the pilot and copilot front and side windows were broken out and consumed by fire. The airplane's fuselage, beginning aft of the pilot seats to the aft cabin bulkhead at FS 304.0, was broken aft, fragmented, charred, and melted. The main cabin door at FS 187.0 was broken out, fragmented, and charred. The bottom portion of the door was consumed by fire. The door latch was found in the closed and locked position. The right side emergency window hatch was broken out, fragmented, and consumed by fire. The cabin windows were broken out and consumed by fire. The cabin seats were broken out from the floor. The seat cushions were consumed by fire. The seat frames were twisted, and fragmented, charred, and melted. The cabin floor was broken aft, fragmented, and charred. The cabin floor, carpet, and interior walls and ceiling were consumed by fire. The airplane's left wing was broken aft, crushed, fragmented, charred, and melted. The inboard wing section between wing station (WS) 36.0 and WS 145.75 was crushed aft, charred, and melted. The left flap was broken out and consumed by fire. The top and bottom speed brakes were broken out, charred, and melted. The outboard wing section was crushed aft, charred and melted. The left aileron was crushed aft and consumed by fire. The left aileron bellcrank was charred and melted. Aileron control cables were fragmented and charred. Cable fragments were unraveled at the fractures. Flight control continuity to the left aileron was confirmed. The left main landing gear and a 7-foot section of the center wing carry-through spar were suspended in the upper level of the dairy storage rack, forward and above the airplane main wreckage. The gear and spar section were charred and melted. The airplane's right wing was broken aft, fragmented, charred, and melted. The right main landing gear and gear door were broken out. The main landing gear uplocks were broken out and charred. The right flap was broken out, bent upward, charred, and melted. The top and bottom speed brakes were broken out, charred, and melted. The right aileron was broken out a
The pilot not maintaining aircraft control while maneuvering after takeoff and the pilot's inadequate preflight planning and preparation. Factors relating to the accident were the pilot's diverted attention while maneuvering after takeoff, the pilot's attempted VFR flight into instrument meteorological conditions, the pilot's visual lookout not being possible, the low ceiling, snow, and fog, the airplane's low altitude, and the building.
Source: NTSB Aviation Accident Database
Aviation Accidents App
In-Depth Access to Aviation Accident Reports
