Swanton, OH, USA
N183GA
Dassault Aviation DA-20
The flight crew of the Fan Jet Falcon (DA-20) were practicing ILS approaches in instrument meteorological conditions with low clouds and rime ice. A first officer (FO) in training occupied the right seat, while the pilot-in-command (PIC), who was also the company chief pilot/check airman/designated flight instructor, occupied the left seat and was handling the radios. On the second approach, the airplane struck trees and burned, 1.57 nm from approach end of the runway. The landing gear was found extended, and the trailing edge and droop leading edge flaps were retracted. The wing and engine cowl anti-ice valves were found closed, consistent with it being off in the cockpit. Radar data revealed that on approach, the airspeed decreased from 188 knots to 141 knots at the outer marker, and continued to decrease down to 106 knots, when the airplane entered an abrupt descent and disappeared from radar. Simulator flights matched the radar profile with a flight idle approach, a power reduction inside the outer marker, and 1/4 inch of ice on the wings. In the simulator, the airplane stalled about 2 miles from the end of the runway with an airspeed of 103 kts. At flight idle, the engine power in the last 2 minutes of approach was below the recommended power setting for wing or engine anti-ice to be effective. Vref and stall speeds were computed to be 129 kts and 96 kts, with wing flaps and droop leading edges retracted. The PIC had about 1,100 hours in the make and model. The PIC did not have any documented previous flight instruction experience in make and model or any other multi-engine airplanes. The PIC had given 4 pilot proficiency checks in the DA-20 since receiving his check airman designation. The company Director of Operations reported that the accident FO was the first student the PIC had taken through the initial second-in-command course. The PIC and FO had received all of their turbojet experience with the operator.
HISTORY OF FLIGHT On April 8, 2003, at 1349 eastern daylight time, a Dassault Fan Jet Falcon (DA-20), N183GA, operated by Grand Aire Express Inc. (GAE), as flight 183, was destroyed when it struck trees while on an instrument approach to Toledo Express Airport (TOL), Swanton, Ohio. The two certificated airline transport pilots, and pilot rated passenger were fatally injured. Instrument meteorological conditions prevailed for the instructional flight, which last departed from Cherry Capital Airport (TVC), Traverse City, Michigan. The flight was conducted on an instrument flight rules (IFR) flight plan under 14 CFR Part 91. According to the Director of Operations (DO) for Grand Aire Express, the flight was dispatched from Toledo with a 14 CFR Part 135 qualified flight crew on board, and a first officer in training (FO), who occupied the jump seat with no required duties. According to records from the Federal Aviation Administration (FAA), prior to departure from Toledo, the direct user access terminal system (DUATS) was accessed using a Grand Aire logon. Selected notices to airmen (NOTAMS), terminal forecasts (TAFs), and aviation routine weather reports (METARS) were requested by the logon user. The airplane then flew from TOL to Grand Rapids (GRR), Michigan, where cargo was loaded. There was no servicing while the airplane was on the ground at Grand Rapids. However, flight service was contacted by the flight crew and an IFR flight plan was filed to Traverse City. The latest weather for Traverse City, and their alternate airport was also requested. When asked if any additional weather was needed, the offer was declined. There were no reported problems on the flight between Grand Rapids and Traverse City. While on the ground at Traverse City, the airplane was serviced with 150 gallons of Jet-A aviation grade turbine fuel. Flight service was again contacted by the flightcrew and an IFR flight plan to Toledo was filed. No weather information was requested. The return flight to Toledo was planned as an instructional flight for the FO, who was being prepared for his 14 CFR 135, second-in-command checkride. The pilot-in-command (PIC) occupied the left seat. He was the company chief pilot, an FAA designated check airman, and a company designated flight instructor. The FO in training occupied the right seat, and the 14 CFR Part 135, DA-20 qualified first officer occupied the jump seat, as a pilot rated passenger with no required duties. There were no reported problems with the departure or en route phases of the flight. The pilots initially contacted Toledo Approach Control at 1324. The pilots initiated a practice ILS approach to runway 07, with the intent to perform a missed approach. During the missed approach, the airplane was radar vectored for a second ILS approach to runway 07. The air/ground communications tape between the airplane and approach control was reviewed. The director of operations identified the voice that was responding to radio calls as the PIC. According to an FAA transcript of air/ground communications, at 1345:29, Grand Aire flight 183 was requested to maintain 180 knots to TOPHR, the final approach fix. This instruction was acknowledged by the PIC. At 1346:21, flight 183 was instructed to maintain 2,300 feet until established on the localizer, and cleared for the ILS runway 07 approach. The flight was again instructed to maintain 180 knots to TOPHR. This was acknowledged by the PIC. At 1348:51, the arrival controller transmitted, "grand air one eighty three, contact tower." At 1348:54, the PIC transmitted, "tower, grand air one eight three." No further transmissions were received from the airplane, and radar contact was lost. A witness driving south on a road, adjacent to the west side of Oak Openings Preserve Park, reported that she saw the airplane on final approach. She described it as lower than normal, and north of the final approach course. She stopped her vehicle, stepped out, and watched the airplane fly overhead. She reported that she could hear a popping noise as the airplane passed overhead. As the airplane disappeared from view, she thought she heard a power reduction from the engines. She then got into her vehicle and did not see or hear anything else. A second witness who was located north of the localizer approach course reported that the tops of the trees, which were 80 to 100 feet high, were obscured by fog. He could hear the engines running intermittently, interspaced with "bangs." A third witness reported hearing a noise, which she described as, "like a huge drum of nuts and bolts, and you shook it. It was very, very loud and then silence." A ground search was initiated, and the airplane was located about 1415. The accident occurred during the hours of daylight at 41 degrees, 34.371 minutes north latitude, and 83 degrees, 51.815 minutes west longitude. PERSONNEL INFORMATION Pilot-In-Command The PIC held an airline transport pilot certificate for multi-engine airplanes, and a type rating for the DA-20. He held a commercial pilot certificate with ratings for single engine airplanes, rotorcraft helicopter, and instrument helicopter. He also held a flight instructor certificate with ratings for single and multi-engine, and instrument airplane. He was last issued a first class FAA airman medical certificate with no limitations on April 2, 2003. According to the company, the PIC's total flight experience was 4,829 hours, with 4,384 hours as PIC. His total DA-20 experience was 1,100 hours including 923 hours as PIC. He had flown 82 hours in the preceding 90 days, and 28 hours in the preceding 30 days. The PIC also held a mechanic's certificate with airframe and powerplant ratings. The PIC completed initial training in the DA-20 on April 22, 2000. His last recurrent ground school was completed on May 3, 2002. His last proficiency check in the DA-20 occurred on January 3, 2003. First Officer The FO held an airline transport pilot certificate for multi-engine airplanes and a type rating for the EMB-120. He held a commercial pilot certificate with a single engine rating. He also held a flight instructor certificate with a single engine rating. He was last issued a first class FAA airman medical certificate with no limitations on February 27, 2003. According to the company, the FO's total flight experience was 4,632 hours, including 2,000 hours as PIC, and 7.1 hours in make and model. He had flown 63 hours in the preceding 90 days, and 21 hours in the preceding 30 days. The FO completed DA-20 ground school on April 2, 2003. Prior to the accident flight, he had received 7.1 hours of dual instruction in the DA-20, all from the PIC. He started flight training on March 13, 2003, and his last instructional flight prior to the accident was on April 2, 2003. AIRCRAFT INFORMATION The type certificate data sheet referred to the airplane as a Fan Jet Falcon. The airplane was originally equipped with two General Electric CF 700-2C engines, and had been upgraded to the CF 700-2D2 engines by service bulletin. The wings were equipped with trailing edge flaps, and droop leading edges (DLE) on the outboard half of the wings. The fuel system consisted of two wing tanks, and two rear compartment tanks located aft of the aft pressure bulkhead, and between the engines. The wing tanks held 552 gallons on each side, and the rear compartment tanks held 71 gallons on each side. The airplane had been converted from passenger carrying to a freighter by removal of the main cabin door, and the interior liner and seats. Entrance to the airplane was through the cargo door, forward of the leading edge of the left wing. There were three methods to exit the airplane. The main cargo door and the sliding left side direct vision window in the cockpit could both be used as an emergency exit. In addition, there was an overhead plug type emergency exit which measured 18.5 inches wide, and 13.5 inches deep. This emergency exit was located behind the pilot seats and in front of the cockpit jump seat. METEOROLOGICAL INFORMATION Interviews with the pilots of two airplanes that were following the accident airplane revealed they had their anti-ice systems ON at the time of the accident. One pilot reported light to moderate rime ice, between 1048 and 1210, while operating in the Toledo area. When he returned to Toledo, he did not notice any ice buildup on the airplane. The other pilot reported rapidly building rime ice, and he requested an altitude change to avoid the ice. A meteorological factual report was completed by a Safety Board Meteorologist. According to the report, there was no frontal activity. However, there was an area of low pressure, with high humidity. In addition, the surface temperatures were near freezing over Michigan and Northern Ohio. The report also listed six pilot reports from the Toledo area, between 0707 and 1215. Five of the reports listed light to moderate rime ice, and the tops of the overcast to be between 5,000 feet and 6,000 feet. The airplanes ranged from single engine airplanes not approved for flight in icing conditions, to a Gulfstream IV in which the crew reported moderate rime ice. The 1333 Special weather observation at Toledo included winds from 300 degrees at 9 knots, visibility 1 statue mile, mist, ceiling 300 feet overcast, temperature 0 C, dewpoint -1 C, remarks, surface visibility 1 1/4 statute miles. The 1352 METAR weather observation at Toledo included winds from 300 degrees at 9 knots, visibility 1 statue mile, mist, ceiling 300 feet overcast, temperature 0 C, dewpoint -1 C, remarks, surface visibility 1 3/4 statute miles. According to the terminal forecast for Toledo issued at 0958, between 1200 and 1500, the visibility was forecast to be 3 statute miles and included freezing drizzle, and mist, and a ceiling of broken clouds at 500 feet. The terminal forecast that was contained in the DUATS weather received by the pilot, forecast that between 1200 and 1600, the visibility would be 4 statute miles with freezing drizzle, mist, and a ceiling of broken clouds at 500 feet. When the accident flight made initial contact with approach control, they reported that they had airport terminal information service (ATIS) TANGO. The ATIS was updated twice, first with UNIFORM, and then with VICTOR, as the pilots performed practice approaches. On the first approach, the control tower gave the flight the latest runway visual range (RVR). ATIS TANGO - Issued 1255:26 reported: "toledo express information tango, one seven zero zero metar, weather, wind zero two zero at niner, visibility three, mist, ceiling 500 overcast, temperature zero, dew point minus one, altimeter three zero two six, i l s runway seven approach in use, all airborne aircraft contact toledo approach on one three four point three five, on initial contact advise that you have tango." ATIS UNIFORM - Issued 1327:49 reported: "toledo atis information uniform, one seven two four zulu special weather observation, wind zero one zero at one two, visibility one, mist, ceiling five hundred overcast, temperature zero, dew point minus one, altimeter three zero two five, i l s runway seven approach in use, advise on initial contact you have information uniform." ATIS VICTOR - Issued 1339:15 reported: "toledo atis information victor, one seven three three zulu special weather observation, wind zero two zero at niner, visibility one, mist, ceiling three hundred overcast, temperature zero, dew point minus one, altimeter three zero two six, i l s runway seven approach in use, advise you have information victor." AIDS TO NAVIGATION The glideslope for the ILS runway 7 approach was set at 3 degrees. The glideslope altitude over the outer marker was 2,168 feet msl. A flight check was performed by the FAA on the ILS runway 7 approach to Toledo airport on April 18, 2003. The results were satisfactory. FLIGHT RECORDERS The airplane was not equipped with a cockpit voice recorder, or flight data recorder, nor was it required by regulations. RADAR AND OTHER REMOTELY RECORDED DATA CDR radar data was received from the Toledo TRACON. The rate of rotation on the antenna was about 4.5 seconds, and recorded altitudes represented the airplane's received altitude, plus or minus 50 feet. The radar data was reviewed by a Performance Engineer with the Safety Board. At 1446:32.56, the airspeed of the airplane was 188 KCAS, the altitude was 2,700 feet, and airplane was about 3 miles from the outer marker. At 1447:42.07, the airplane passed over the outer marker at 2,300 feet, and 141 KCAS. Between 1348:19.15, and 1348:28.22, the airplane momentarily leveled at 1,800 feet, and then continued in a descent that progressively increased in rate as the airspeed continued to decrease. The recorded altitude change between the last two radar contacts was 300 feet down. The last radar contact occurred at 1349:00.7, with a recorded altitude of 900 feet, and an airspeed of 106 KCAS. This radar contact was 1.77 nautical miles from the approach end of runway 07. The published airport elevation was 684 feet. WRECKAGE AND IMPACT INFORMATION The airplane was examined at the accident site on April 9, and 10, 2003. The examination revealed that the airplane impacted trees, and came to rest on level ground, 1.57 nautical miles from the approach end of runway 07. The debris trail measured 360 feet from the first tree strike, to the nose of the airplane. The airplane and debris trail were on a magnetic heading of 060 degrees. Multiple trees were broken, in a descending flight path angle of about 20 degrees, which led to the airplane. The three landing gear were separated from the airplane, and laying nearby. Gouges in the dirt that corresponded to the position of both main landing gear were found adjacent to the tail of the airplane. The condition of the landing gear was consistent with the landing gear being extended at ground impact. A post crash fire consumed the fuselage. Major components including the cockpit center pedestal, crew seats, forward and aft cargo compartment bulkheads, and the rear compartment fuel tanks were destroyed by fire. The cargo door was distorted, and open about 2 inches at the base. The door was blocked from further opening by a tree adjacent to the left side of the fuselage. The left side direct vision (DV) window was found in the open position. The fuselage structure located above the cockpit windows, including the overhead instrument panel, upper escape hatch, aft pressure bulkhead, and upper fuselage, to the vertical stabilizer were destroyed by fire and not identified. Both engines were mounted to their respective pylons, and the pylons had separated from the fuselage structure. The engine cowlings were in place, and exhibited burn damage. The compressor and fan section of each engine could be rotated. The tips of the first stage of compressor blades were bent in the opposite direction of rotation on both engines. The fuel shutoff valve for the left engine was halfway closed, and attached to the engine. The cable that actuated the shut off valve was melted at a cable connection. The right engine fuel shut off valve was separated from the engine and found partially covered by melted aluminum debris. The vertical and horizontal stabilizer were attached to the fuselage. The elevator trim jackscrew was found set at 4.5 degrees, which corresponded to the bottom of the green arc for takeoff. Both wings had separated from the fuselage, and were fragmented into multiple pieces. The pieces were scattered along the debris trail with the outboard sections located first. The inboard sections were found closer to the main wreckage. The wing flaps were positioned by three jackscrews on each wing. Five of the six jackscrews were identified, and all were in the retracted position, which corresponded to the wing flaps retracted. The two locking hydraulic cylinders that control extension and retraction for the wing DLEs were found locked in the retracted position. MEDICAL AND PATHOLOGICAL INFORMATION The toxicological testing report
The flight instructor's inadequate supervision of the flight, including his failure to maintain an approach airspeed consistent with the airplane's configuration, which resulted in an aerodynamic stall due to slow airspeed, and subsequent uncontrolled descent into trees. Factors were the icing conditions, the flight instructors failure to turn on the wing and engine anti-ice, and his lack of experience as an instructor pilot in the airplane.
Source: NTSB Aviation Accident Database
Aviation Accidents App
In-Depth Access to Aviation Accident Reports
