North Vernon, IN, USA
N19D
CESSNA A185F
After a 100-hour inspection, which the pilot assisted with, he conducted an operational check of the airplane, which included a run-up of the airplane. The mechanic had to leave before the inspection was complete, and the pilot installed portions of the interior which included the fuel selector handle. He then departed the airport and after retracting the landing gear and flaps, the engine lost power. During the forced landing the airplane sustained substantial damage to the empennage and aft section of the fuselage. Examination of the airplane revealed that fuel was available in the left and right fuel tanks. The examination also found that the fuel selector handle had been installed incorrectly by 90° on the fuel selector shaft. The position of the shaft as found would have restricted all fuel flow from the left and right fuel tanks. The shaft was “keyed” such that the fuel selector handle should only be installed one way; however, the handle partially fit over the stem when not aligned with the key on the shaft and allowed the attaching screw to partially engage on the stem. An engine test run was conducted; the engine started normally and with the engine at full throttle, the fuel selector was placed in the left, right, and both positions. The engine continued to run with no anomalies noted. The airplane was factory equipped with a small header tank that fuel accumulated in before being fed to the engine. The accident is consistent with the fuel selector shaft being in the off position while the selector handle pointed to the left fuel tank. Once the fuel in the airplane’s header tank was exhausted, the engine lost power due to fuel starvation.
On April 16, 2021, about 2030 eastern daylight time, a Cessna A185F amphibian airplane, N19D, was substantially damaged when it was involved in an accident near North Vernon, Indiana. The pilot was not injured. The airplane was operated as a Title 14 Code of Federal Regulations Part 91 personal flight. The pilot reported that he assisted a mechanic with a 100-hour inspection, and he then conducted an operational check of the airplane, which included an inspection and a run-up of the airplane. He then departed and after retracting the landing gear and flaps, the engine lost power. Unable to make it back to the airport, he selected a nearby golf course for the forced landing. The airplane sustained substantial damage to the empennage and aft section of the fuselage. Examination of the airplane by a Federal Aviation Administration (FAA) inspector revealed that the left fuel tank contained 10 gallons of fuel and the right fuel tank contained 15 gallons of fuel. The inspector reported that the mechanic had to leave work early, and the pilot installed portions of the interior which included the fuel selector handle. Examination of the fuel selector handle found that the handle had been installed incorrectly by 90° on the fuel selector shaft. The fuel selector shaft was “keyed” so that the fuel selector handle could be installed in only one way; however, the handle partially fit over the stem and allowed the attaching screw to partially engage on the shaft. The inspector removed the fuel selector handle and provided a photo of the selector as orientated, when found (see Figure 1). The fuel selector handle was on the left tank position, but the orientation of the fuel selector shaft as positioned restricted all fuel flow to the engine. Figure 1: Fuel valve selector (FAA photo) A post-accident engine test run was conducted with the engine operated at full throttle; the fuel selector was placed in the left, right, and both positions. The engine operated with the fuel selector in each of these positions with no anomalies noted. The airplane was factory equipped with a small header tank that collected fuel before being fed to the engine.
The pilot’s improper installation of the fuel selector handle, which resulted in a total loss of engine power due to fuel starvation.
Source: NTSB Aviation Accident Database
Aviation Accidents App
In-Depth Access to Aviation Accident Reports
